EZGO Gas Fuel System Problems | Golf Cart Garage I Episode # 51

Link To Website: https://www.golfcartgarage.com/

Please click on the link below to schedule a call with Tim:
https://www.golfcartgarage.com/gearhe...

00:00 - 𝗜𝗻𝘁𝗿𝗼

01:51 - 𝗤:𝟬𝟭- Cart master battery disconnect issue - Just bought a 2013 EZGO TXT 36v and want to install a MASTER battery disconnect. What do you advise?

03:07 - 𝗤:𝟬𝟮 - Cart rear-facing seat issue - I recently bought a Yamaha golf cart, serial # JC2-206167. It came with the rear-facing seats on the back where clubs would normally go. I removed the seat and am trying to find the original basket and club holder; it is more difficult than I thought it would be. Any help would be much appreciated.

04:25 - 𝗤:𝟬3 - How to achieve cart full speed - EZ GO 48V Golf Cart-Can't achieve full speed. Just watched your Youtube video on charger troubleshooting. I recently replaced the solenoid in the cart; since then, I can't get the cart to go full speed. Any suggestions on what I should check?

05:33 - 𝗤:04 - Cart Volt meter issue - Need some technical support. I have a 2014 Club Car Precedent. The 12-volt system has a constant draw on the batteries. The only 12-volt accessory on the cart is the light kit. I installed a new voltage converter and when I hook up the power wire to the battery it still throws a big spark with everything turned off. The Volt meter measured between the battery post and the converter power wire shows 48 volts going to the converter even when there is nothing turned on. Took the cart to a local shop and they said this is normal. Does that sound right to you? This means the battery has a drain on it 24/7 even when it is not being used.

08:00 - 𝗤:𝟬5 - Cart controller issue - I have 2 carts that have stopped running (2007 Precedent). With the run/tow switch on rolling the carts back and forth, there is no alarm sound or resistance. I wonder if replacing a controller with a running cart would be valid.

10:27 - 𝗤:𝟬6 - Cart reverse buzzer issue - My cart has a long delay or doesn't go at all when you start. I have a new battery but I noticed the reverse buzzer does work.

12:04 - 𝗤:𝟬7 - Cart forward/reverse switch issue - Forward/reverse switch is about a year old. 2005 EZ GO TXT 1- the switch is very stiff to move with the hand lever. 2- when moved to the forwarding position the cart will move. When moved to the reverse position it takes several times back and forth with the hand lever and it will finally connect and move in reverse. I don’t see any burnt or hot marks on the switch. Someone said to spray it down with WD40 but I’m afraid to try that.

14:10 - 𝗤:𝟬8 - Cart fuel system issue - EZ Go Gas Fuel system problems. I have an EZGO Gas workhorse (2004). It starts and runs ok but seems to start choking down and
will only run at about 1/2 power when it warms up.

16:40 - 𝗤:𝟬9 - Cart not moving forward/reverse issue - I live in The Villages, Fl, and noticed that some mornings the golf cart engine will not start (fwd/reverse) with 1st push of a gas pedal.
I do not hear any type of click. Usually, the second push of the gas pedal will start it. I removed the accelerator switch, and pushing the button feels like it works, and its rubber boot looked good. Suggestions?

19:11 ​- 𝗢𝘂𝘁𝗿𝗼

Thanks for stopping by the garage!